Windshield wiper door stays open ???
Forum: C3 Electrical, Body and Interior
14 Messages
Page 2 of 2
Sponsored Content
m
Lifetime Member
Send PMEquinunk, PA - USA
Joined: 10/31/2007
Posts: 2570
Vette(s): 1972 conv, 4-speed, 350, 200hp, numbers match, rally wheels, war bonnett yellow w/white top. good condition, nice driver.
There is a vacuum diverter valve under the dash by your knees that is used to keep the doors open for repairs once the vacuum bleeds down. One for the lights, one for the wipers. There may be a difficulty with it also. You can also operate the doors by hand from under the car for lights, and the rubber plug on the diaphragm canister for the wiper door can be pulled out and the ram pushed by hand/finger to open the door. Just push it down when done, and replace the plug.
Be the first to like this post
Sign In to Like this post
Sign In to Like this post
SPONSOR AD:: (Our Sponsors help support Vette Registry)
r
The problem will be your Actuator Relay. I had a similar problem but it was with the headlight door. I replaced the check valve thinking it might be the problem. NO!
Turned out to be the new Actuator relay that was faulty.
You can also check your wiper door Actuator with a vacuum tester. The outside vacuum hose towards the front of the car will close the door with vacuum suction, and the inside towards the windshield will open the door.
On a 68 you only have one actuator valve for your headlights. You probably have two. If you can block off this and use this same actuator for your wiper doors(which is the same actuator) then you can determine what the problem is. A very easy process.
Be the first to like this post
Sign In to Like this post
Sign In to Like this post
J
Free Member
Send PMMAPLE, Canada
Joined: 3/9/2008
Posts: 164
Vette(s): 70 VETTE 350/300HP, AUTOMATIC, ALL STOCK EXCEPT FOR MILD CAM,LAGUNA GREY, 3:55 POSI GEARS
Replaced vacuum check valve...problem solved.
Be the first to like this post
Sign In to Like this post
Sign In to Like this post
Lifetime Member
Moderator
Send PMModerator
Duncanville, TX - USA
Joined: 11/8/2003
Posts: 22714
Vette(s): #1-1974 L-48 4spd Cp Med Red Metallic/Black deluxe int w/AC/tilt/tele./p/w-p/b/
Am-Fm/map light National/Regional/Chapter NCRS "Top Flight"
#2-1985 Bright Red/Carmine Cp.L-98/auto
Member: NCRS, NCRS Texas, Corvette Legends of Texas
Joel Adams
C3VR Lifetime Member #56 
My Link 
(click for Texas-sized view!) NCRS
"Money can't buy happiness -- but somehow it's more comforting to cry in a CORVETTE than in a Kia"
Be the first to like this post
Sign In to Like this post
Sign In to Like this post
in Forum: C3 Electrical, Body and Interior
Sponsored Content